Author Topic: exhaust valve main rod  (Read 2675 times)

0 Members and 1 Guest are viewing this topic.

Offline mustangfury

  • Full Member
  • ***
  • Posts: 143
exhaust valve main rod
« on: May 17, 2010, 11:44:10 AM »
Hi on my 93 k125 i have oil coming out through the main rod that sticks out the side of the cylinder from the exhaust valve assembly.  I know it must be the seal or the o ring on the valve guide. What i call the valve guide is the guide on the main rod that is held in by the little screw head that overlaps its edge.

Here is a schematic.  Valve guide: #49002. Seal: #92049.
http://www.petescycle.com/fiche_section_detail.asp?section=380051&category=Motorcycles&make=KAWASAKI&year=1993&fveh=8784

Now, my question is, should the valve guide that the o ring sits on be in there really tight or should it be loose.  Mine is loose.  If you pull the shaft, you can see it wobbling.  I am going to get a new seal, does the guide need replacing too or is that normal? 
1993 KX 125

Offline Coop

  • Full Member
  • ***
  • Posts: 107
Re: exhaust valve main rod
« Reply #1 on: May 18, 2010, 12:46:00 AM »
I always replace the o-ring and seal on the power valve anytime I service the top end. They go bad.

That guide should be tight, you should have to give it a good push to get it to go in and seat (the o-ring causes the tight seal).
"Twenty years from now, you will be more disappointed by the things that you didn't do than by the ones you did do"- Mark Twain

1997 CR80RB, 1993 KX60, 1988 KX125

Offline mustangfury

  • Full Member
  • ***
  • Posts: 143
Re: exhaust valve main rod
« Reply #2 on: May 18, 2010, 01:12:45 AM »
so does it just need a new o-ring and new seal you think?
1993 KX 125

Offline Coop

  • Full Member
  • ***
  • Posts: 107
Re: exhaust valve main rod
« Reply #3 on: May 18, 2010, 01:32:13 AM »
I think so, yes. Two stroke oil gets on those PV parts from the cylinder and the o-ring and seal are there to keep it on the inside and not leaking out all over the cylinder.
"Twenty years from now, you will be more disappointed by the things that you didn't do than by the ones you did do"- Mark Twain

1997 CR80RB, 1993 KX60, 1988 KX125

Offline mustangfury

  • Full Member
  • ***
  • Posts: 143
Re: exhaust valve main rod
« Reply #4 on: May 18, 2010, 02:34:48 AM »
yeah, mine has been leaking out all over the cylinder for a while now.  I'll try just replacing the o ring and seal and see what happens.
thanks for the help.
1993 KX 125

Offline Coop

  • Full Member
  • ***
  • Posts: 107
Re: exhaust valve main rod
« Reply #5 on: May 18, 2010, 04:29:14 AM »
Sure thing, hope that gets you fixed up.
"Twenty years from now, you will be more disappointed by the things that you didn't do than by the ones you did do"- Mark Twain

1997 CR80RB, 1993 KX60, 1988 KX125