Author Topic: sleeve/cylinder deck height question  (Read 4974 times)

0 Members and 1 Guest are viewing this topic.

2001KX5

  • Guest
sleeve/cylinder deck height question
« on: April 29, 2006, 01:11:29 PM »
The sleeve in my 91 cylinder is sitting just below the deck of the cylinder.  I can just catch a nail it so maybe like 1 thousandth.

Should the sleeve height be 100% flush with the cylinder deck height? Could this cause coolant problems? Should I get the deck trued so the heights match?
« Last Edit: April 30, 2006, 12:21:48 AM by 2001KX5 »

Offline Arigato

  • Hero Member
  • *****
  • Posts: 516
Re: sleeve/cylinder deck height question
« Reply #1 on: April 29, 2006, 02:09:32 PM »
I don't know if it will affect cooling. However, it will create detonation issues.

2001KX5

  • Guest
Re: sleeve/cylinder deck height question
« Reply #2 on: April 30, 2006, 12:57:09 AM »
Do you mean as it is now or if I get 1 thou taken milled off the cylinder deck?

The slack could very well be taken up by the head gasket.

Offline Arigato

  • Hero Member
  • *****
  • Posts: 516
Re: sleeve/cylinder deck height question
« Reply #3 on: April 30, 2006, 02:35:19 AM »
I mean with it the way it is now.

Offline YUNGGUNNAZ

  • Full Member
  • ***
  • Posts: 219
Re: sleeve/cylinder deck height question
« Reply #4 on: May 01, 2006, 12:55:54 AM »
have deck cut to 0 deck hgt.surface should be flush across imo.

2001KX5

  • Guest
Re: sleeve/cylinder deck height question
« Reply #5 on: May 01, 2006, 01:12:49 PM »
cylinder was dropped off today at the machine shop to mill the deck of the cylinder down to the sleeve height.  This is more for sealing purposes and well to prevent any detonation issues.  There is barely a gap there, less than 0.008 thou based on my feeler gauge.  They are also putting heli coils in some of the thread holes that are questionable.

Jesus I just want to ride!

Offline hughes

  • Hero Member
  • *****
  • Posts: 1,923
    • Dirt Hammers
Re: sleeve/cylinder deck height question
« Reply #6 on: May 01, 2006, 02:37:07 PM »
Hang in there you will get that bike back together and it will be ready to ride.
Open Class 2-Stroke Kawasaki KX500
Yamaha 2005 YZ250
Richard Hughes
Dirt Hammers - Online Off-Road Journal
hughes@dirthammers.com
http://www.dirthammers.com

2001KX5

  • Guest
Re: sleeve/cylinder deck height question
« Reply #7 on: May 05, 2006, 08:41:58 AM »
Had the cylinder deck milled and 9 heli coils put in. It seems to fine now.

Had abuot an hours run last night and I'm impressed.

I find that compared to my buddies 03 CR250 the 500 is much easier to ride.  I like the broad power range. Now it certainly don't rev out like a 250 but jesus its powerfull!  Now I'm running a 14/51 sprocket combination because it suits most of the trails I ride on so I know a 49 or 47 tooth rear sprocket would make thing thing a speed demon. But it chugs in 2 and 3rd gear no problem and just blip the gasola any time you want to say hello to the front tire.

On decel with the throttle just about fully let off she surges up in rpm a little, its tolerable.  I'm running a 168 main, stock needle in 3rd position and a 55 pilot with the air screw about 1 1/4 turn out. It has a sleeve and Eric Goor mobetter porting with boyseen super stock reeds and a twin air filter. They are the only mods, well my cyilnder was miiled so my comp. should be up a little.

She starts and idles fine (which is strange for the 500?) and revs up to the top just fine. It doesn't feel rich or lean at any point in the throttle range but I haven't done a plug test. I may try another 1/4 turn on the air screw to see if it take it away some but its really really minor imo.

I have read that a bit of surging is fine and some say that its an indication of having jetting dialed in. If any one has any comments on my jetting it would be good. I'm just at sea level and temps range from 5-25 deg C.
« Last Edit: May 05, 2006, 08:53:27 AM by 2001KX5 »